|本期目录/Table of Contents|

[1]冯　健,余军霞,吴晓燕,等.风化壳淋积型稀土矿浸出液草酸沉淀稀土母液去除草酸的研究[J].武汉工程大学学报,2021,43(02):163-168.[doi:10.19843/j.cnki.CN42-1779/TQ.202009011]
　FENG Jian,YU Junxia,WU Xiaoyan,et al.Removal of Oxalic Acid from Rare Earth Oxalate Precipitation Mother Liquor of Weathered Crust Elution-Deposited Rare Earth Ore Leachate[J].Journal of Wuhan Institute of Technology,2021,43(02):163-168.[doi:10.19843/j.cnki.CN42-1779/TQ.202009011]
点击复制

风化壳淋积型稀土矿浸出液草酸沉淀稀土母液去除草酸的研究(/HTML)
分享到：

《武汉工程大学学报》[ISSN:1674-2869/CN:42-1779/TQ]

卷:
43
期数:
2021年02期
页码:
163-168
栏目:
化学与化学工程
出版日期:
2021-04-30

文章信息/Info

Title:
Removal of Oxalic Acid from Rare Earth Oxalate Precipitation Mother Liquor of Weathered Crust Elution-Deposited Rare Earth Ore Leachate
文章编号:
1674 -2869（2021）02 -0163 -06
作者:
冯　健1; 2; 余军霞2; 3; 吴晓燕1; 2; 周　芳2; 4; 徐源来1; 2; 池汝安*2; 4
1. 武汉工程大学化工与制药学院，湖北 武汉 430205；2. 绿色化工过程教育部重点实验室（武汉工程大学），湖北 武汉 430205；3. 武汉工程大学化学与环境工程学院，湖北 武汉 430205；4. 武汉工程大学兴发矿业学院，湖北 武汉 430074
Author(s):
FENG Jian1; 2; YU Junxia2; 3; WU Xiaoyan1; 2; ZHOU Fang2; 4; XU Yuanlai1; 2; CHI Ru’an*2; 4
1. School of Chemical Engineering & Pharmacy，Wuhan Institute of Technology，Wuhan 430205，China；2. Key Laboratory of Green Chemical Engineering Process of Ministry of Education（Wuhan Institute of Technology），Wuhan 430205，China；3. School of Chemistry and Environmental Engineering，Wuhan Institute of Technology，Wuhan 430205，China；4. School of Xingfa Mining Engineering，Wuhan Institute of Technology，Wuhan 430074，China
关键词:
风化壳淋积型稀土矿; 草酸; 沉淀; 稀土母液复用
Keywords:
weathered crust elution-deposited rare earth ore; oxalic acid; precipitation; rare earth mother liquor reuse
分类号:
TD865
DOI:
10.19843/j.cnki.CN42-1779/TQ.202009011
文献标志码:
A
摘要:
通过草酸沉淀回收风化壳淋积型稀土矿浸出液中稀土后的沉淀母液，含有大量的浸取剂硫酸铵和过量草酸，直接排放不仅浪费浸取剂，而且会引起氨氮废水污染；直接用于回浸稀土矿，会由于草酸含量高而影响稀土的浸出，因此必须去除草酸后再复用。本文筛选了去除草酸的钙类去除剂，探讨了不同去除剂用量和陈化时间条件下草酸的去除效果，探索了去除草酸后回浸液对稀土浸出率的影响。对比氯化钙、氢氧化钙和碳酸钙对沉淀稀土后母液中残留草酸的去除率发现，氢氧化钙效果最好。生产上通常沉淀稀土母液草酸质量浓度都在0.8 g/L以下，较佳的去除草酸工艺参数为氢氧化钙与草酸的物质的量之比为2，陈化时间为3 h，得到回浸液中草酸质量浓度在0.08 g/L以下。回浸液中补加硫酸铵使其质量分数达到2%后再用于风化壳淋积型稀土矿的浸出，稀土的浸出率达93%以上，表明回浸液对稀土的浸出率影响很小，完全可以循环使用。本研究实现了稀土浸出液沉淀稀土后母液的循环使用，提高了风化壳淋积型稀土矿开采的经济效益。
Abstract:
Rare earth oxalate precipitation mother liquor after recovering the rare earth in the weathered crust elution-deposited rare earth ore leachate by the oxalic acid precipitation method still contains a large amount of leaching agent ammonium sulfate and excess oxalic acid. Discharging mother liquor will cause waste and ammonia-nitrogen pollution. When the precipitation mother liquor which still contains oxalic acid was directly used as the leaching liquor，the residual oxalic acid， especially with high concentration，may decrease the leaching efficiency of rare earth. Therefore oxalic acid must be removed before the recycle. In this paper，the screening of calcium-based removal agents for oxalic acid was carried out. The effects of removal agent dosage and aging time on oxalic acid removal rate were discussed and the effect of the precipitation mother liquor after removal of oxalic acid on the leaching rate of rare earth was investigated. Comparing the removal rates of excess oxalic acid by calcium chloride，calcium hydroxide and calcium carbonate，it was found that calcium hydroxide showed the better performance. The oxalic acid mass concentration of the rare earth oxalate precipitation mother liquor during the production is generally below 0.8 g/L. The optimized oxalic acid removal process is that the ratio of calcium hydroxide to oxalic acid is 2 and the aging time is 3 h. After removing excess oxalic acid by calcium hydroxide，the reused leaching liquor is obtained with the low mass concentration of oxalic acid below 0.08 g/L. Ammonium sulfate was added to the reused leaching liquor to a mass fraction of 2%，and then used as the leaching agent for the weathered crust elution-deposited rare earth ore. The leaching efficiency of rare earth from weathered crust elution-deposited rare earth ore is above 93%. It is indicated that the precipitation mother liquor after removal of oxalic acid has little effect on the leaching efficiency of rare earth and can be recycled in the mines completely. These results realize the recycling of rare earth oxalate precipitation mother liquid，and can improve the economic benefits of weathered crust elution-deposited rare earth ore mining.

参考文献/References:

［1］　池汝安，田君，罗仙平，等. 风化壳淋积型稀土矿的基础研究 ［J］. 有色金属科学与工程，2012，3（4）：1-13.

［2］　ZHANG Z Y，HE Z Y，YU J X，et al. Novel solution injection technology for in-situ leaching of weathered crust elution-deposited rare earth ores ［J］. Hydrometallurgy，2016，164：248-256.
［3］　何正艳，张臻悦，余军霞，等. 风化壳淋积型稀土矿浸取过程中稀土和铝及铵的行为研究 ［J］. 稀土，2015，36（6）：18-24.
［4］　张臻悦，何正艳，徐志高，等. 中国稀土矿稀土配分特征 ［J］. 稀土，2016，37（1）：121-127.
［5］　YU B Z，HU Z Y，ZHOU F，et al. Lanthanum（Ⅲ）and yttrium（Ⅲ）adsorption on montmorillonite：the role of aluminum ion in solution and minerals ［J］. Mineral Processing and Extractive Metallurgy Review，2020，41（2）：107-116.
［6］　ZHOU F， FENG J， XIE X， et al. Adsorption of lanthanum（III） and yttrium（III） on kaolinite：kinetics and adsorption isotherms［J］. Physicochemical Problems of Mineral Processing，2019，55（4）：928-939.
［7］　池汝安，田君. 风化壳淋积型稀土矿评述 ［J］. 中国稀土学报，2007，25（6）：641-650.
［8］　池汝安，田君. 风化壳淋积型稀土矿化工冶金［M］. 北京：科学出版社，2006.
［9］　CHI R A，TIAN J. Weathered crust elution-deposited rare earth ores ［M］. New York：Nova Science Publishers，2008.
［10］　冯健，何正艳，周芳，等. 某风化壳淋积型稀土矿的渗透性研究［J］. 稀土，2017，38（4）：50-59.
［11］　LIU X， ZHOU F ，CHI R A， et al. Preparation of modified montmorillonite and its application to rare earth adsorption ［J］. Minerals，2019，9（12）：747：1-14.
［12］　HE Z Y， ZHANG Z Y， YU J X， et al. Process optimization of rare earth and aluminum leaching from weathered crust elution-deposited rare earth ore with compound ammonium salts ［J］. Journal of Rare Earth，2016，34（4）： 413-419.
［13］　HE Z Y， ZHANG Z Y， YU J X， et al. Kinetics of column leaching of rare earth and aluminum from weathered crust elution-deposited rare earth ore with ammonium salt solutions［J］. Hydrometallurgy，2016，163：33-39.
［14］　ZHOU F， LIU Q， FENG J， et al. Role of initial moisture content on the leaching process of weathered crust elution-deposited rare earth ores ［J］. Separation and Purification Technology，2019，217：24-30.
［15］　FENG J，ZHOU F，CHI R A，et al. Effect of a novel compound on leaching process of weathered crust elution-deposited rare earth ore ［J］. Minerals Engineering，2018，129：63-70.
［16］　ZHOU F， FENG J， WANG Z， et al. One step purification of impurities in the leachate of weathered crust elution-deposited rare earth ores ［J］. Physicochemical Problems of Mineral Processing，2017，53（2）：1188-1199.
［17］　武汉大学.分析化学实验［M］. 5版. 北京：高等教育出版社，2011.
［18］　陆永绥.尿钙和草酸盐测定中的取样误差：草酸钙在盐酸-尿混合物中的溶解度［J］.国外医学（临床生物化学与检验学分册），1984（1）：53-54.
［19］　张培萍，刘丽华，董峻岭，等.草酸钙的形成机理及影响因素［J］.白求恩医科大学学报，2001，27（5）：567-569.
［20］　张丽丽，邓祥义，丁一刚，等.碳酸氢铵制备晶型混合碳酸稀土的工艺研究［J］.黄石理工学院学报，2011，27（5）：20-24.

相似文献/References:

备注/Memo

备注/Memo:
收稿日期：2020-09-16基金项目：国家自然科学基金-云南联合基金重点项目（U1802252）；国家自然科学基金重点研发计划专项（2018YFC1801800）；国家自然科学基金重点项目（51734001）作者简介：冯　健，博士研究生。E-mail：15071246881@163.com*通讯作者：池汝安，博士，教授。E-mail：rac_511@163.com引文格式：冯健，余军霞，吴晓燕，等. 风化壳淋积型稀土矿浸出液草酸沉淀稀土母液去除草酸的研究［J］. 武汉工程大学学报，2021，43（2）：163-168，180.
更新日期/Last Update: 2021-04-26